Yamaha YZF-R125 Service Manual: Removing the throttle body

1. Extract the fuel in the fuel tank through the fuel tank filler hole with a pump.

2. Disconnect:

  • Fuel hose
WARNING

Cover the fuel hose connections with a cloth when disconnecting them. Residual pressure in the fuel lines could cause fuel to spurt out when removing the hoses.

NOTE:

  • To remove the fuel hose from the fuel injector, slide the fuel hose connector cover "1" on the end of the hose in the direction of the arrow shown, press the two buttons "2" on the sides of the connector, and then remove the hose.
  • Remove the fuel hose manually without using any tools.
  • Before removing the hose, place a few rags in the area under where it will be removed.

Removing the throttle body


3. Remove:

  • Throttle body
CAUTION:

Do not remove the throttle body sensor assembly "1" from the throttle body.

Removing the throttle body


Checking the fuel injector

1. Check:

  • Fuel injector Damage Replace.

    Throttle body
    ...

    Checking the throttle body
    1. Check: Throttle body Cracks/damage Replace the throttle body. 2. Check: Fuel passages Obstruction Clean. a. Wash the throttle body in a petroleum-based solvent. Do not us ...

    Other materials:

    Checking and lubricating the cables
    The following procedure applies to all of the inner and outer cables. WARNINGDamaged outer cable may cause the cable to corrode and interfere with its movement. Replace damaged outer cable and inner cables as soon as possible. 1. Check: Outer cable Damage Replace. 2 ...

    Outline of the fi system
    The main function of a fuel supply system is to provide fuel to the combustion chamber at the optimum air-fuel ratio in accordance with the engine operating conditions and the atmospheric temperature. In the conventional carburetor system, the air-fuel ratio of the mixture that is supplied t ...

    Lubricating the drive chain
    The drive chain consists of many interacting parts. If the drive chain is not maintained properly, it will wear out quickly. Therefore, the drive chain should be serviced, especially when the vehicle is used in dusty areas. This vehicle has a drive chain with small rubber O-rings between eac ...

    2024 Copyright www.yam-r125.net |